I had mentioned in a previous post on the expense of foam upholstery padding. After a little research on the net, in an attempt acquire the materials cheaper and of better quality than what can be found at JoAnne's Etc., it became obvious that finding them through CList was the best route to take financially. Purchasing and parting out the Coleman Newport camper made a lot of sense as the padding alone would have cost about $150-200 and this didn't count the OSB backer boards or the upholstery!
I had a little free time a couple days ago so I used it sizing the longer than required seat cushions from the Newport to fit the dinette seating of the Banner.
The end result looks as if it came with the camper straight off the production line. The only exception is that the pads are bit wider and therefore they don't lay perfectly flat when converted to the bed. I thought about cutting down one of the pads, but liked the coverage of the current dimensions. So, we'll see how the craftmatic-bed like pillow area is over a night's sleep and adjust later if need be.
I've got a couple more things I'm going to try my best to get done this week as well. There is a stainless steel tank in one of the seat compartments that I'm going to remove. It was part of a "Steven's" pressurized water delivery system that is found on many of these old time campers. The pressurized systems are prone to leak as the copper tubing and fittings age. I'd have to inspect every run and squeeze into some confined areas underneath the camper, in the walls and in some of the cabinets. A scenario that I'm going to pass on. We'll have water at Trout Camp via an auxiliary tank. I'll likely run new flexible tubing and use a gravity fed delivery system for both the sink and shower. It'll be something that we can use when we're there and take down and store when we're not. Having a tank out in the open just invites destruction and/or damage whether on purpose or by accident. Over the course of removing the 12volt air pump that pressurizes the water tank, I was able to finally locate the source of that sweet yet rancid smell in the camper. I'm hoping that I don't find more, but it is unbelievable on how one dead field mouse in a semi-enclosed compartment can make an entire camper reek so badly! He's found a new resting place and purpose; fertilizer in the garden!
I'd also like to remove and resell the 510A Dometic Propane fridge. It isn't in incredibly bad shape, but whether it works or not is the question. I'm sure there is someone out there in CList land that'll buy it and I'll use the proceeds toward the re-roofing in the spring.
Finally, there is another galvanized tank under the fridge that I believe to be the "gray" water tank. That'll be removed as well after the fridge comes out.
I'll put up some photos later this week to show you the removal steps and progress.
Well, this trip was bittersweet. On the way into camp Saturday evening, I was informed that my wife was driving my 10 year old son to ER for stitches. While playing some aggressive football with the neighbor's son and friends a head-on collision occured. My son's eyebrow got the brunt of the force exerted by the other player's teeth. The result was the peeling down of his eyebrow from the midline out toward the right side of his brow ridge.
I'm happy to say that a dozen stitches fixed him all up. And, the report I got, was the ER at Hillcrest treated him well and did a great job. He's still swollen and the blood is beginning to drift down and under his eye. In a couple more days, he should have a nice shiner to go with the son of Frankenstein stitches he's sporting. Poor guy! What a bruiser though!
So, with that on my mind and a whole host of other stresses that I'm trying my best to cope with....traveling to trout camp was supposed to be a welcome relief. But, I can honestly say that I didn't feel the stress reduction that normally magically happens upon crossing the Ohio / Pennsylvania border this time around. There were just too many things going on for me to attempt to forget. The calming / healing properties of Trout Camp weren't working on this trip. I'm hoping that it was me and not lost majical properties at our little hide-away in the hills.
The buzz at the local tavern was the influx of bear hunters. Jim and I hadn't seen this packed in like forever. In a stroke of luck we were able to snag a table just as some patrons finished up and left. We ordere our "usuals" and chased it with a couple of ice cold bottled Yings. We spoke to a few guys in from Ohio and made small talk about football and dealt with the "flat landers" comments from the locals. Even the Steelers fans seemed to be optimistic that in a couple years our Brownies might be up to the task of walking on the field and battling it out like we had years ago when the rivalry was bitter and a celebrated event. We can only hope that we're on the right track now with the current staff. I believe we are.
Jim and I headed up to camp and went through our normal routine of scoping out the property and prepping for snoozing in the Mountaineer. I quickly took note of the overturned 55 gallon drum and the scattering of all our trash that we had left. What had scavenged our refuse? Raccoon, deer, cougar or maybe even a bear? Who knows? Whatever it was, it was strong, because that steel drum isn't the lightest thing to topple over! I was hoping that the culprit wouldn't show while we were up there either! I spent a few minutes cleaning up the place which wasn't so difficult. The full moon in the sky was shining a bright blue hue down on the woods. Almost all the leaves have fallen and the lush fern vegetation has taken on a rust-brown color. It was very cool out causing ice crystals of frost to form just about everywhere. The frosty white color reflected the moon's radiance effectively. Within a few minutes, my eyes adjusted to the point that I could see anything and everything without the use of a headlamp. I won't forget that pale blue hue though. It seemed to just make everything glow eerily.
Jim and I also took notice that someone had traveled via our gravel road. The rock we laid down smoothly just a month ago had settled some and the surface was scarred by a half dozen thin wheel marks. They seemed far to thin for quad, automobile or wheelbarrow. I'm guessing that it was either a dirt bike or game cart pulling out a prized kill? Any trace of the wheel tracks was erased with a quick once over by the rake.
The next morning, bright and early, coffee was served, a bagel was eaten and the next installment of 10# of gravel arrived and was spread. During the course of our discussion with our local excavator contact, Jim and I made mention of some flattening that we'd like done in preparation of the Banner Camper's arrival next spring. A short while into the video, you'll see me pointing out to Steve our ideas and what we're were looking to accomplish. Steve quoted us on the spot and with a very reasonable amount. If the stars align, we may just have him back to camp with his track hoe to level things out. I had considered borrowing my buddy Greg's Kubota again, but the time and energy, gas, etc associated with it just didn't make sense. Steve told us that he'd be able to push everything down, stumps and all, level things off, smooth the drive in and out all in one day. What he'd be able to do with his heavy machinery would take me and the little tractor many trips and alot of work. It just makes sense to go with a professional. I can't tell you how happy I am that Jim and I were referred this gentleman and his abilities. He's reasonable, on time, makes special delivery accomodations (Sunday mornings) and has worked out great for TC improvements.
I shot a video of the second go round with the gravel delivery, the before and after of the full drive and a little bit of what TC looks like now that all the vegetation is pretty much dead and void of green. It is boring, but I'm sure someone will enjoy seeing our progress and speedy work in fast forward mode. I can't wait to shoot Steve down there with the track hoe pushing out the stumps, the hillside and anything else in his way. That is a "Bob the Builder Day" for sure!
Sitting on the sidelines, I've waiting patiently for the perfect moment to pounce on another great CL find. It would appear, for at least the last couple months, that every opportunity had several others waiting to make the grab as well. Almost like a broken record, either the item was sold minutes prior or would sell before I could punch out of work and make the journey to acquire it! As a matter of adaptation, my searches were broadened to include Erie, Youngstown, Akron/Canton, Ashtabula as well as Cleveland.
Finally the stars aligned and another Craig's List find made it back home with me. On Sunday, my son and I traveled to South Akron and hitched up a 1984 Coleman Newport. You might be thinking to yourself, why does Dj (don't forget Floatman too!) need another camper? And you would be correct, we really don't need another camper! LOL! But, we do need a hauling trailer and we definitely needed the four pads that complement the dinette area of the 22' Banner. Without them, let's just say sitting on 3/4" plywood and a vertical back rest is very uncomfortable! Not to mention, converting the dinette to sleeping would have all the luxuries of a foreign prison bed!
If you have ever researched upholstery padding, you know that it isn't cheap! The good stuff is a small fortune and then you have to become a seamstress to make the covers. Well, I can sew, but this isn't as simple as putting a button back on a shirt. Finding a set of seat cushions that would fit the size we needed for the Banner was a priority. Another nagging "want" was a trailer that Floatman and I could use to tow supplies up to camp as needed and facilitate trips to H.Depot when we make building additions to the property (steps coming off the deck anyone?). Plus, Floatman, Packmule and I are planning on a doing a inflatible pontoon trip down a class A stocked trout stream in late spring of 2011 and we need a way to haul the pontoons! This pop-up fulfills them all!
The Newport is slightly larger than my Columbia and comes equipped with a 9.5' long box, so naturally the pads for the dinette are longer than we need which works out great. Another benefit is the longer box makes for a longer trailer frame which is really great. The previous owner tried to convince me that all it needed was a new tree and cable hoist system, but once I pried the top off...it was evident that it needed A LOT more than that. I'm very glad that I wasn't purchasing it for camping purposes or the $200 I spent would have been waisted and my hopes at camping dashed. It was a pleasant reminder that the $250 I spent on the Columbia several years ago was money well spent and reinforced what a great deal I got on that one.
It took me and my son about 5 hours to dismantle the popup parts and remove them from the trailer. I meticulously chopped up the pieces into sizes that could be disposed of properly. I have no doubt that the aluminum and steel will be on my tree lawn for only a few minutes. The area's traveling metal recycler is quite efficient when it comes to picking through everyone's trash of valuable scrap. It is a "service" I don't mind as the trash collector usually rejects anything that can't be hidden within a can or bagged.
My hopes are that the parts that I was able to salvage through the tear down and relist on CL will sell, thus lowering the amount of my investment to the point that Floatman and I can say we got the padding and the trailer for free. We'll see, it is the end of the camping season. Many of them may sit in the garage until spring of next year, but that's ok!
Recap:
It's not free, but here is what a $250 1984 Coleman Newport Pop-up Camper gets you:
(4) perfectly matched seat/backpads for the Banner's dinette/bed area
(2) 3" foam queen size mattresses for use in the Banner.
(1) 7' X 9' long utility trailer frame w/brand new tires (I forgot to mention that!)
(1) Full set of privacy drapes for the Columbia camper (since they were removed due to age)
(1) Entrance door with door-to-canvas seals that are in perfect condition (I'll swap the door with mine and sell the door on CList) These plastic pieces sell for $30 a side at the RV store!!!!
I had a little free time a couple days ago so I used it sizing the longer than required seat cushions from the Newport to fit the dinette seating of the Banner.
